The 1MW powerplant will be mounted on a De Havilland Dash 8-100 turboprop aircraft, scheduled to perform its first test flight in 2024. The engine and its technology will allow for more efficient engine performance during the different phases of flight, such as take-off, climb and cruise.
The goal of the battery-electric powertrain is to reduce fuel burn and CO2 emissions by 30% compared to a standard Dash-8 turboprop.
I was wondering "why just two props" when reading this, thanks. Because they're reusing an existing airframe makes a lot of sense, even if a lot of benefits from electric airplanes come from adding more, smaller props.
Yes exactly - I think the idea is to give a way forward for existing airframes to use more efficient engines. The fact they are hybrid is irrelevant to the owner, they just see lower running costs.
This and most recent articles on the demonstrator are frustratingly light on details. Found some more info on Wikipedia's article on hybrid electric aircraft [0] which cites an Aviation Week article [1] that is unfortunately behind a paywall
> One 2,150 hp (1,600 kW) PW121 turboprop will be replaced by a 1 MW (1,300 hp) gas turbine joined with an electric motor of the same rating, powered by off-the-shelf lithium-ion batteries for takeoff and climb. The turbine is used alone in cruise and drives the motor-generator to recharge the batteries in descent. The downsized engine operates at its optimum for 30% fuel savings over 200–250 nmi (370–460 km). Range is reduced from 1,000 to 600 nmi (1,900 to 1,100 km) due to the higher empty weight and 50% lower fuel capacity.
I've been disdaining the idea of hybrid aircraft for years, thinking there was no way to capture the energy of deceleration (as you can in a hybrid car). Here, though, the rationale is different; you're storing turbine power during descent for use at the next ascent.
I wonder if you could indeed capture the deceleration energy by having the air stream drive the prop and thus the motor/generator. Planes have multiple systems for wasting energy and slowing down (flaps, air brakes, even dropping the landing gear); perhaps this wasted energy could be put into the batteries?
On a smaller scale, all jet airliners have a RAT (Ram Air Turbine), which is just a propeller that drops into the airstream if both engines fail. It provides hydraulic pressure and electrical power during an emergency.
I don't understand how developing tech for energy recovery makes sense. Why not just idle and descend at a reasonable speed for a reasonable L/D, the way practically all airlines do for practically all routes today? This is energy recovery; turning your altitude into distance traversed.
Hard to believe that putting a vortex-generating turbine and a generator into the airstream will improve efficiency against that.
I don't think that's what the Raytheon prototype is doing. It sounds like they're capturing some of the mechanical energy from the engine during descent and putting that into the battery for later use. Hybrid cars do that, when the driver requests an amount of power too far from the most efficient band they make up the difference by charging/discharging the battery. Knowing the target usage lets the engineers make more aggressive tradeoffs to optimize efficiency for that band.
Hybrid cars' energy regeneration make sense because we must stop/slow down for many reason like crossroad. GP says it's not the case for airplanes. Possibly is military use exception?
It's a common misconception that regenerative braking is the only way hybrid cars charge their batteries. The other common situation is when the driver requests less output from the engine than it can produce efficiently. The engine has a minimum operating speed (say 1000 RPM) and at that speed requires a certain amount of energy just to keep it turning (friction, pumping, etc), in turn making it inefficient at low loads (say 20HP). It turns out that round-tripping energy through the battery is efficient enough to make it worthwhile keep running the engine at close to peak efficiency (say 50HP), send the driver's requested power to the wheels, and store the rest in the battery. Later if the battery is getting full and the driver is requesting little power to the wheels the car can stop the engine and switch to electric until the battery is back to the ideal (around 50%). Knowing this is how the drivetrain behaves the engineers are free aggressively optimize the engine for efficiency only at the speed/torque sweet spot. It's not very intuitive but this chart and Quora article go into more detail:
I think the Raytheon engineers did something similar. You can't turn off the engine during flight so during landing (when the pilot doesn't need so much thrust) they keep running the engine at the sweet spot and store the extra energy in the battery for later use (takeoff). Then optimize the engine design for that sweet spot. There's no braking/deceleration, it's just a way to keep the engine running at close to peak efficiency the whole flight.
When they handle the low hanging fruit of having an electric motor to propel the aircraft from the gate to the runway (bonus points for being able to pushback under their own power) it might become worth while.
Well, part of the reason you start them at the gate is also to test them and warm them up before you get to the most critical part of the flight where you absolutely need to be sure they're going to run: takeoff and initial climb. You don't want to be doing that procedure on the runway for operational reasons.
And some airplanes are already capable of pushing back under their own power. The reason we don't do that is not the plane -- it's the airport. The blast can damage the airport, ground equipment, and endanger people.
In context, a jet engine uses a significant percentage of cruise fuel consumption just idling on the ground. Many airports aircraft can taxi for well over 30 minutes just to reach the runway.
Some record setting flights have been conducted where the aircraft was brimmed on the runway and the manufacturers set minimum times for stabilising the engines before takeoff, circa 30s if I remember correctly.
Issues of blast damage go away if it's propelled by electric power. My understanding is one of the main reasons it isn't often used is that there is a real danger of tipping the aircraft over backwards if the wheel brakes are applied while reversing.
If you want to hybridise an aircraft then starting with electrifying the time spent on the ground is the low hanging fruit.
There's no ingestion risk if it's propelled by electric power, but there's still FOD risk. As I understand, gates in the US have to be specifically designated for powerbacks because of this risk. No matter the method of creating the thrust, if you can move a plane with it, you can blow some object into a person or the airport windows.
It certainly could be done but it would require changes to airports to accommodate it.
Perhaps the reason they need to recharge in descent is less to save energy for the next flight, but more the need to have reasonably well charged batteries in case they need to perform a go-around. Rate of climb when the batteries are discharged is likely to be pretty low. So maybe they will need to operate the turbine at full power while descending to achieve this, whereas normally the engines on a turboprop would be nearer idle in the descent.
If I understand this right, they're still driving the prop mechanically through a gearbox during cruise, rather than using turbo-electric transmission?
That's my understanding. Given that the turbine is used in parallel during takeoff/climb and drives the electric motor as a generator during descent (while presumably still driving the prop) there would need to be a mechanical linkage. Since the linkage is already there, you wouldn't save on weight by using a serial hybrid setup for cruise and the turbine is already sized to be running in an efficient power band for cruise flight.
It seems that for militaries without the budget for helicopters or real tiltrotors like the Osprey a hybrid electric quad tiltroter as a replacement. There are a lot of drawbacks, of course, but I'd think the ease of maintenance and ease of training relative to a real helicopter would be a powerful argument for some countries.
It boils down to getting less range for a given payload for any given aircraft. You can exchange less payload for more range until you have nothing but pilots.
It seems to get equivalent power you need to either exchange a third or so of your range or a significant portion of cargo or a mixture of both.
Hydrocarbons do indeed have significantly more energy density and the benefit that once you’ve used them the weight of the fuel goes away giving you less work to do as your fuel runs out.
The idea that you only need the full power for takeoff is nonsense. You also need it for go-arounds, or fighting strong downdrafts, or if you get seriously and quickly iced up and need full power to simply stay aloft, or if your engine #1 goes out and you need to add power on #2....
Check how MANY checklists for how many situations require full power.
Maybe this has applications for unmanned stuff where it is ok to lose the craft sometimes (which explains Raytheon's interest) but for human carrying, this is idiocy, i say again.
I think you misunderstand. The largest use-case for full-power is takeoff, and that is where the most energy savings comes from having an electric motor assist during the full-power need.
That does not mean that full-power would be unavailable for those other uses you mention.
The batteries are recharged during descent, if I understand correctly. Since "full power" in this craft requires the lithium batteries to be charged, I wonder how much reserve energy will be left in those during cruise for contingency reasons. Perhaps there is plenty left for fighting downdrafts, etc. Unsure.
One nice thing about electric motors is that they can be "throttled up" almost instantaneously, unlike some (not all) turbines. For example, that ultra fast response may be useful in a wind shear situation.
But if the battery is not in ideal state like just after climb up, would that be a problem as the real full power is not really available all the time it seemed.
The goal of the battery-electric powertrain is to reduce fuel burn and CO2 emissions by 30% compared to a standard Dash-8 turboprop.
https://simpleflying.com/raytheon-completes-ground-test-dash...